Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Show: south west rr meet at ray west! 2nd feb
Ricky - 130hp dt
Sean - 160hp hdi
Sam - 150hp dt
David - 160/170hp dt
Jamie - 167hp '6
Niall - 129bhp
Chris - 165bhp '6
Ozone - 150hp dt
Frosty - 150hp S16
MIKE-FORD - 112bhp hdi
Poodle - 120bhp HDi
306 HDi Deathtrap - 130bhp / 220lbft
...UPGRADING...



Reply
Thanks given by:
Ricky - 130hp dt
Sean - 160hp hdi
Sam - 150hp dt
David - 160/170hp dt
Jamie - 167hp '6
Niall - 129bhp
Chris - 165bhp '6
Ozone - 150hp dt
Frosty - 150hp S16
MIKE-FORD - 112bhp hdi
Poodle - 120bhp HDi
Kwik - 125bhp DT

And i'm gonna be here early as I am leaving at 2am and gonna bum about in services! want to shoot by 1pm as i got work in evening
Don't worry about what I'm doing, I want you to worry about what you're doing
Reply
Thanks given by:
Not long now guys Big Grin
[Image: fe6eddc8-1731-4100-a5fe-1edb853a88b6_zpseeacf928.jpg]
Reply
Thanks given by:
Looking forward to it, not looking forward to my car's turn...
GT2052s DTurbo
OEM+ HDI Estate
Project thread
Reply
Thanks given by:
Not the only one haha dont want it to blow up
[Image: fe6eddc8-1731-4100-a5fe-1edb853a88b6_zpseeacf928.jpg]
Reply
Thanks given by:
I'm trying to tune it to keep the EGT's down, it's quite slow now Sad
GT2052s DTurbo
OEM+ HDI Estate
Project thread
Reply
Thanks given by:
That sucks Sad bet its well boggy now
[Image: fe6eddc8-1731-4100-a5fe-1edb853a88b6_zpseeacf928.jpg]
Reply
Thanks given by:
Hmm, sort of, it's definatly smoke free, I just need to adjust the LDA pin to get a perfect compromise, my pin is very harsh so too much preload and it's rubbish to drive and causes a lot of lag low down.
GT2052s DTurbo
OEM+ HDI Estate
Project thread
Reply
Thanks given by:
(31-01-2013, 07:13 PM)sam Wrote: Not the only one haha dont want it to blow up

power runs arnt too harsh on the car, its just a slow build up then max throttle for a few seconds, just like overtaking really.

its dyno tuning which is very hard on an engine, long amounts of time spent near or on the limiter to record information, thats what can potentually cause damage, but just a few power runs is no different from a 3rd or 4th gear overtaking spree Smile
Current stable
'09 Mercedes E320cdi wagon 
'99 306 gti6
Reply
Thanks given by:
Hmm, I've never used the whole of 4th, and I'm guessing on the dyno they do? As long as they don't floor it at very low revs, this turbo spools so early it will slip my paddle clutch, so I dread to think what it will do to the engine!
GT2052s DTurbo
OEM+ HDI Estate
Project thread
Reply
Thanks given by:
anyone with any good maps on there laptop for hdi please bring and will chuck some ££ as feel the one i got from longlife isnt as good as i was expected Sad
Reply
Thanks given by:
ECU number?
Welding and fabrication projects undertaken, contact me for more information.

Reply
Thanks given by:
i think power readings are done by "sweep" testing, its when they build upto a certain rpm then build upto a specified end rpm in a continuous sweep. 3rd gear usually i think which is good as we all know how good the 3rd gear pull is with a tuned xud Smile
Current stable
'09 Mercedes E320cdi wagon 
'99 306 gti6
Reply
Thanks given by:
575 are the last numbers mate (i think thats rite)
Reply
Thanks given by:
Anyone else going from Exeter/Taunton area?
Reply
Thanks given by:
Is there any chance someone can bring down a lap top with a good battery. My current stage 1 isn't quite the full fat version (hence the figures below) and if i can get a full fat one in time I hope i can upload it on the day. Meed to make sure shes alright on the lesser map first though.


Ricky - 130hp dt
Sean - 160hp hdi
Sam - 150hp dt
David - 160/170hp dt
Jamie - 167hp '6
Niall - 129bhp
Chris - 165bhp '6
Ozone - 150hp dt
Frosty - 150hp S16
MIKE-FORD - 112bhp hdi
Poodle - 120bhp HDi
Kwik - 125bhp DT
Dum-Dum 175bhp and 400nm (2.2HDi)

Poodle theres no way i believe 120 from a car with a R70 pump




(31-01-2013, 11:23 PM)ozonehostile Wrote: i think power readings are done by "sweep" testing, its when they build upto a certain rpm then build upto a specified end rpm in a continuous sweep. 3rd gear usually i think which is good as we all know how good the 3rd gear pull is with a tuned xud Smile

Nah they pull off (as you would driving and keeping the revs low) then just keep it pinned till it hits the limiter or the power starts dropping. Its done in whichever gear is closest to a 1:1 ratio which for 95% of cars including ours is 4th.

running in 3rd will give you an over optomistic figure.
Reply
Thanks given by:
so basically mans with maps on laptops bring them and make some ££ unless kind hearted Smile
Reply
Thanks given by:
(31-01-2013, 11:45 PM)Dum-Dum Wrote: Nah they pull off (as you would driving and keeping the revs low) then just keep it pinned till it hits the limiter or the power starts dropping. Its done in whichever gear is closest to a 1:1 ratio which for 95% of cars including ours is 4th.

running in 3rd will give you an over optomistic figure.

ah cool, knew it was something like that, only ever been present at dyno tuning so just watching a car been held on the limiter for hours
Current stable
'09 Mercedes E320cdi wagon 
'99 306 gti6
Reply
Thanks given by:
Ricky - 130hp dt
Sean - 160hp hdi
Sam - 150hp dt
David - 160/170hp dt
Jamie - 167hp '6
Niall - 129bhp
Chris - 165bhp '6
Ozone - 150hp dt
Frosty - 150hp S16
MIKE-FORD - 112bhp hdi
Poodle - 120bhp HDi
Kwik - 125bhp DT
Dum-Dum 175bhp and 400nm (2.2HDi)
Pipps - 160bhp and 360nm (2.0 HDi)

I'll bring my lappy and OBD cable if you like.
Reply
Thanks given by:
how many people are bringing cameras?

my camcorder is on charge Smile
Current stable
'09 Mercedes E320cdi wagon 
'99 306 gti6
Reply
Thanks given by:
I'll be bringing mine Smile Though if everyone would mind sending me the full size photos that would be great, as I'll be aiming to send them on to PFC Wink
Reply
Thanks given by:
We need to make a video for deffinat Big Grin
[Image: fe6eddc8-1731-4100-a5fe-1edb853a88b6_zpseeacf928.jpg]
Reply
Thanks given by:
ive got a hd camcorder than burns straight to a blueray disc, just hope the mic is upto the challenge

(01-02-2013, 12:11 AM)Scott Wrote: I'll be bringing mine Smile Though if everyone would mind sending me the full size photos that would be great, as I'll be aiming to send them on to PFC Wink

jolly good Smile
Current stable
'09 Mercedes E320cdi wagon 
'99 306 gti6
Reply
Thanks given by:
I haven't got it mapped for an R70 pump though mate, and it's still only a stage 1, even if it is a smoky one lol.
306 HDi Deathtrap - 130bhp / 220lbft
...UPGRADING...



Reply
Thanks given by:
(31-01-2013, 11:27 PM)MIKE-FORD Wrote: 575 are the last numbers mate (i think thats rite)

You need a remap before tomorrow? I can make one for you, but not for free Wink
Reply
Thanks given by:
i got a map on it mate from longlife just i was told it was the 125bhp then found that theres is the 112bhp version bud
Reply
Thanks given by:
Only one day togo guys Big Grin whats everyones last minute preps then mine putting everything back together :/
[Image: fe6eddc8-1731-4100-a5fe-1edb853a88b6_zpseeacf928.jpg]
Reply
Thanks given by:
Fixing your car!
[Image: edit2_zpsbe60b3ca.jpg]

Team derv FLAME and CONROD spitters
Reply
Thanks given by:
(01-02-2013, 09:45 AM)David Wrote: Fixing your car!

Haha yeah boyo think of puttin the k14 on for now scared of running a turbo without running it in Sad
[Image: fe6eddc8-1731-4100-a5fe-1edb853a88b6_zpseeacf928.jpg]
Reply
Thanks given by:
An stick the over turbo on it mate and take it easy today. The turbo should be fine from straight away as long as we primer it before starting it
[Image: edit2_zpsbe60b3ca.jpg]

Team derv FLAME and CONROD spitters
Reply
Thanks given by:


Possibly Related Threads…
Thread Author Replies Views Last Post
  South west pugfest convoy Frosty 7 1,999 29-06-2017, 12:35 PM
Last Post: Frosty
  GI: South West Meet Up mr_fish 69 17,282 02-12-2016, 11:17 PM
Last Post: Sian
  Show: South West Auto Sport - May 15th - Newton Abbot (SouthWest) silverzx 3 2,524 22-04-2016, 12:50 PM
Last Post: Frosty

Forum Jump:


Users browsing this thread: 1 Guest(s)