Citroen Berlingo 1.9DT - For Sale 10 month MOT £650 ono

[Jenkosowls]

So worst kept secret! We now have and xud9te engine in! About a week after buying the van I bought a cheap engine of eBay complete engine out of a 405 for £65 a week I sold the Bosch that was on it for £110 as I'd already purchased a Bosch.

My original plan was just to bang a Bosch on and run it as a nad on veg cheap motoring. But as it needed a new cambelt water pump head gasket etc etc I just thought stick a Dt engine it.

Slowly collected a few bits over 9months I'v had it just waiting on the engine to let go. Eventually it did after un known reasons. But was time to drop it in.

So crummy dw8


Empty bay


Xud9te


Swooping diffs


All done


Best place for a nad in the skip!


Did it over 2 days had a few problems one being when I swamped the diffs for some strange reason the driveshafts wouldn't fit so pulled engine out again as it was only in place eventually sorted it then found out the 405 box wouldn't go in reverse!

So rather than stick the crummy nad box in I sourced an emergency box from a 306 to use. Sorted! Took a while to start up as I have no fuel grenade but it ran! Currently appears clutch is slipping, have a water leak from water pump slightly leaking sump. This is due to using a sealant 2 months ago that ideally needs heat to set. Instead it's gone brittle and failed. Other than that it's nice to be boôsting again!

Few things to sort out are

Reseal water pump
Reseal sump
Sort exhaust
New gear box seals
New clutch